2. Universidad Cardenal Herrera-CEU

Using agricultural by-products such as dehydrated orange pulp (DOP) in animal feeds is of interest to increase pig sector sustainability. With this aim, an assay was carried out to assess the effects of increasing inclusion levels of DOP in pig diets regarding animal performance, carcass quality, and environmental impact. Four experimental diets were designed, a control diet (T1) and three more diets with increasing levels of DOP with 80, 160, and 240 g/kg of DOP for diets T2, T3, and T4, respectively. One hundred and sixty growing pigs were used in the experiment. Growth performance (average daily gain, ADG; average daily feed intake, ADFI and feed conversion ratio, FCR) and in vivo backfat thickness (BF) and loin depth (LD) gain were recorded during the finishing phase (from 70 to 130 kg BW). Faecal samples were incubated for bacteria enumeration. At slaughter, carcass characteristics and meat quality traits were measured, and subcutaneous fat was sampled to analyse the fatty acid (FA) profile. Additionally, the slurry excreted by the animals was measured, characterised and subjected to a gaseous emission assay during its storage. The final BW and overall ADFI, ADG and FCR were similar among treatments. In vivo final LD and BF gain decreased (P 0.10) as the inclusion level of DOP increased. No differences were observed in carcass characteristics with the inclusion of DOP, except carcass weight that decreased linearly (P = 0.05) with DOP. Regarding the FA profile of the subcutaneous fat, the ratio of total monounsaturated to saturated FA increased with the inclusion level of DOP. Neither slurry excretion and characterisation nor bacterial counts from faeces showed any significant difference among treatments. The inclusion of DOP led to greater CH4 emissions in mg per L of slurry and hour, whereas these differences disappeared when expressed in mg per animal and day. In all, it has been demonstrated that the inclusion of DOP up to 240 mg/kg in pig diets had minor effects on growth performance, carcass quality traits or gaseous emissions from slurry, favouring the circular economy strategy and pig sector sustainability.

The inclusion of orange pulp (OP) in pig diets may promote the circular economy, but drying procedures might influence its nutritional value and environmental impact. The purpose of this study was to determine the energy value and nutrient digestibility of dehydrated (DOP) and ensiled sun dried (ESDOP) orange pulp. The potential ammonia (NH3) and methane (CH4) emissions derived from slurry were also measured. Digestible energies of 14.2 and 13.2 MJ/kg DM for DOP and ESDOP, respectively, were estimated by difference after a 500 g/kg substitution of a basal diet with OPs. A high fiber digestion efficiency was observed for both OPs. Pigs fed the basal diet showed a higher intake and a greater excretion of urine N than pigs fed with OP, but fecal N excretion did not differ among diets. A higher benzoic and hippuric acid content in urine was observed in OP than in basal diet. Altogether, these findings explained a lower pH in slurry of OP diets and a reduction of potential NH3 emissions. The biochemical CH4 potential also decreased, especially with ESDOP. Overall, both OP are relevant sources of energy for pig diets. Their inclusion in feeds generate favorable changes of slurry characteristics that reduce potential NH3 and CH4 emissions.

One of the key factors to improve swine production sustainability is the use of agro-industrial by-products in feeds, such as olive by-products. However, it is necessary to assess its effects on the overall production process, including the animal and the environment. With this aim, an experiment was conducted to determine the effects of including a partially defatted olive cake (PDOC) in pig diets on growth performance, faecal microbiota, carcass quality and gas emission from the slurry. Two finishing diets were formulated, a control (C) diet and a diet with PDOC included at 120 g/kg. Eighty finishing male pigs Duroc-Danbred × (Landrace × Large White) of 60.4 ± 7.00 kg BW were divided between these two treatments. During the finishing period (60 to 110 kg BW, 55 days) average daily gain, average daily feed intake and feed conversion ratio were recorded. Faecal samples from the rectum of 16 animals per treatment were incubated for bacteria enumeration. At the end of finishing period, backfat thickness and loin depth (LD) were measured. Animals were slaughtered to obtain carcass weight and carcass composition parameters, and subcutaneous fat was sampled to analyse the fatty acid (FA) profile. In addition greenhouse gas and ammonia emissions were measured during pig slurry storage using the methodology of dynamic flux chambers. An initial slurry characterisation and biochemical methane potential (B0) were also determined. No significant differences between treatments were found in performance, carcass quality and microbial counts with the exception of LD, which was lower in PDOC compared with C animals (45.5 v. 47.5 mm, SEM: 0.62; P = 0.020). The FA profile of the subcutaneous fat did not differ between treatments, but the monounsaturated FA (MUFA) concentration was higher and the polyunsaturated FA was lower in the animals fed PDOC (50.9 v. 48.3, SEM: 0.48, P < 0.001; 17.6 v. 19.3, SEM: 0.30, P < 0.001 in mg/100 g of Total FA, for PDOC and C animals, respectively). The initial pig slurry characterisation only showed differences in ADF concentration that was higher ( P < 0.05) in the slurry from PDOC treatment. Regarding gas emission, slurries from both treatments emitted similar amounts of ammonia (NH3), carbon dioxide (CO2), methane (CH4) and nitrous oxide (N2O), as well as B0 values. The results obtained suggest that PDOC may be included in balanced pig diets at rates of up to 120 g/kg without negative effects on performance, carcass quality, gut microflora and slurry gas emission, while improving the MUFA concentration of subcutaneous fat.